Basic tuning requires that you start smaller than optimum and keep enlarging main jets a step (or two) at a time until your top speed (or dyno...
Never blame a fuel pump until you've tried bypassing the (often faulty) pump relay ! I tried gravity feed on an '86 and had too many problems,...
I'd be pleased to go through those carbs with my finest fine-tooth comb if you need professional help.
You can't be sure the pilot jets are clear until you've put a .010" steel wire through the holes. Can't be sure idle mixture screw passages are...
Be sure the powder coater covers up the holes where wheel bearings go !!!
OEM Honda steering bearings usually get all wobbly and worn out by about 25,000-30,000 miles and need replacing.
That's why, whenever i'm cleaning carbs for a VFRW member, i always ask them to drain and flush out their fuel tank befor refitting carbs.
Alot of parts that you might need are unavailable.........
Squirrelman fixes VFR carbs too, works faster than Mr. Bill and charges only $175 for the same service.
Routing is CRITICAL, and factory manual is best source for info. I think your problem is related cables having insufficient freeplay in return cable.
Use a flashlight to check for any excessive carbon deposits on the back of valves. Be sure the mounting boots are positioned correctly. Carbs...
Just as that guy ^^ sez, likely problem (if it's not spark-related) is cloggted slow jets or mixture screw passages in carbs.
Glad to see other NASCAR/Sprinter fans on here !! Apparently, Toe Cutter is a close match for Stewart except in temperment.
A brake tune up should be done periodically to remove glaze from pads and clean road grease from the rotors..........as you discovered. Pad...
Anytime you run out of fuel, it's a great idea to drain the float bowls as water and filth from the bottom of the tank will have moved...
If the starter clutch housing isn't cracked, it's possible to order repair parts:springs & rollers. Must disassemble for inspection. Find a...
bingo !!!!!!
^^ Best advice you'll get !!
Answer is YES !
Squirrelbrains can't afford a car or another insurance, but will drive this antique on selected summer days after my partial engine rebuild is...
Separate names with a comma.
